Doe Science news source
The DOE Science News Source is a Newswise initiative to promote research news from the Office of Science of the DOE to the public and news media.
  • 2018-01-02 13:30:05
  • Article ID: 687358

A Fossil Fuel Technology That Doesn't Pollute

Process can use coal, shale gas and biomass while consuming carbon dioxide

  • Credit: Photo by Jo McCulty, courtesy of The Ohio State University.

    New materials under development at The Ohio State University, including a patented iron oxide particle (left), are enabling cleaner fossil fuel technologies.

  • Credit: Photo by Jo McCulty, courtesy of The Ohio State University.

    Andrew Tong, research assistant professor of chemical and biomolecular engineering at The Ohio State University, examines equipment in the Clean Energy Research Laboratory.

  • Credit: Photo by Jo McCulty, courtesy of The Ohio State University

    L.S. Fan, Distinguished University Professor in Chemical and Biomolecular Engineering at The Ohio State University, holds samples of materials developed in his laboratory that enable clean energy technologies.

In the first of two papers published in the journal Energy & Environmental Science, the engineers report that they’ve devised a process that transforms shale gas into products such as methanol and gasoline—all while consuming carbon dioxide. This process can also be applied to coal and biomass to produce useful products.

Under certain conditions, the technology consumes all the carbon dioxide it produces plus additional carbon dioxide from an outside source.

In the second paper, they report that they’ve found a way to greatly extend the lifetime of the particles that enable the chemical reaction to transform coal or other fuels to electricity and useful products over a length of time that is useful for commercial operation.

Finally, the same team has discovered and patented a way with the potential to lower the capital costs in producing a fuel gas called synthesis gas, or “syngas,” by about 50 percent over the traditional technology.

The technology, known as chemical looping, uses metal oxide particles in high-pressure reactors to “burn” fossil fuels and biomass without the presence of oxygen in the air. The metal oxide provides the oxygen for the reaction.

Chemical looping is capable of acting as a stopgap technology that can provide clean electricity until renewable energies such as solar and wind become both widely available and affordable, the engineers said.

“Renewables are the future,” said Liang-Shih Fan, Distinguished University Professor in Chemical and Biomolecular Engineering, who leads the effort. “We need a bridge that allows us to create clean energy until we get there—something affordable we can use for the next 30 years or more, while wind and solar power become the prevailing technologies.”

Five years ago, Fan and his research team demonstrated a technology called coal-direct chemical looping (CDCL) combustion, in which they were able to release energy from coal while capturing more than 99 percent of the resulting carbon dioxide, preventing its emission to the environment. The key advance of CDCL came in the form of iron oxide particles which supply the oxygen for chemical combustion in a moving bed reactor. After combustion, the particles take back the oxygen from air, and the cycle begins again.

The challenge then, as now, was how to keep the particles from wearing out, said Andrew Tong, research assistant professor of chemical and biomolecular engineering at Ohio State.

While five years ago the particles for CDCL lasted through 100 cycles for more than eight days of continuous operation, the engineers have since developed a new formulation that lasts for more than 3,000 cycles, or more than eight months of continuous use in laboratory tests. A similar formulation has also been tested at sub-pilot and pilot plants.

“The particle itself is a vessel, and it’s carrying the oxygen back and forth in this process, and it eventually falls apart. Like a truck transporting goods on a highway, eventually it’s going to undergo some wear and tear. And we’re saying we devised a particle that can make the trip 3,000 times in the lab and still maintain its integrity,” Tong said.

This is the longest lifetime ever reported for the oxygen carrier, he added. The next step is to test the carrier in an integrated coal-fired chemical looping process.

Another advancement involves the engineers’ development of chemical looping for production of syngas, which in turn provides the building blocks for a host of other useful products including ammonia, plastics or even carbon fibers.

This is where the technology really gets interesting: It provides a potential industrial use for carbon dioxide as a raw material for producing useful, everyday products.

Today, when carbon dioxide is scrubbed from power plant exhaust, it is intended to be buried to keep it from entering the atmosphere as a greenhouse gas. In this new scenario, some of the scrubbed carbon dioxide wouldn’t need to be buried; it could be converted into useful products.

Taken together, Fan said, these advancements bring Ohio State’s chemical looping technology many steps closer to commercialization.

He calls the most recent advances “significant and exciting,” and they’ve been a long time coming. True innovations in science are uncommon, and when they do happen, they’re not sudden. They’re usually the result of decades of concerted effort—or, in Fan’s case, the result of 40 years of research at Ohio State. Throughout some of that time, his work has been supported by the U.S. Department of Energy and the Ohio Development Services Agency.

“This is my life’s work,” Fan said.

His co-authors on the first paper include postdoctoral researcher Mandar Kathe; undergraduate researchers Abbey Empfield, Peter Sandvik, Charles Fryer, and Elena Blair; and doctoral student Yitao Zhang. Co-authors on the second paper include doctoral student Cheng Chung, postdoctoral researcher Lang Qin, and master’s student Vedant Shah. Collaborators on the pressure adjustment assembly work include Tong, Kathe and senior research associate Dawei Wang.

The university would like to partner with industry to further develop the technology.

The Linde Group, a provider of hydrogen and synthesis gas supply and plants, has already begun collaborating with the team. Andreas Rupieper, the head of Linde Group R&D at Technology & Innovation said that the ability to capture carbon dioxide in hydrogen production plants and use it downstream to make products at a competitive cost “could bridge the transition towards a decarbonized hydrogen production future.” He added that “Linde considers Ohio State’s chemical looping platform technology for hydrogen production to be a potential alternative technology for its new-built plants”.

The Babcock & Wilcox Company (B&W), which produces clean energy technologies for power markets, has been collaborating with Ohio State for the past 10 years on the development of the CDCL technology – an advanced oxy-combustion technology for electricity production from coal with nearly zero carbon emissions. David Kraft, Technical Fellow at B&W, stated “The CDCL process is the most advanced and cost-effective approach to carbon capture we have reviewed to date and are committed to supporting its commercial viability through large-scale pilot plant design and feasibility studies. With the continued success of collaborative development program with Ohio State, B&W believes CDCL has potential to transform the power and petrochemical industries."

Editor's note: Additional images are available to the news media for download.

X
X
X
  • Filters

  • × Clear Filters

Columbia Researchers Squeeze Light into Nanoscale Devices and Circuits

Columbia investigators have made a major breakthrough in nanophotonics research, with their invention of a novel "home-built" cryogenic near-field optical microscope that has enabled them to directly image, for the first time, the propagation and dynamics of graphene plasmons at variable temperatures down to negative 250 degrees Celsius. If researchers can harness this nanolight, they will be able to improve sensing, subwavelength waveguiding, and optical transmission of signals.

Self-Assembling 3D Battery Would Charge in Seconds

A cross-campus collaboration led by Ulrich Wiesner, professor of engineering at Cornell University, has resulted in a novel energy storage device architecture that has the potential for lightning-quick charges for electronic devices.

Understanding the Generation of Light-Induced Electrical Current in Atomically Thin Nanomaterials

Scientists added an imaging capability to Brookhaven Lab's Center for Functional Nanomaterials that could provide the optoelectronic information needed to improve the performance of devices for power generation, communications, data storage, and lighting.

Diamond 'Spin-Off' Tech Could Lead to Low-Cost Medical Imaging and Drug Discovery Tools

An international team led by scientists at Berkeley Lab and UC Berkeley discovered how to exploit defects in nanoscale and microscale diamonds and potentially enhance the sensitivity of magnetic resonance imaging and nuclear magnetic resonance systems while eliminating the need for their costly and bulky superconducting magnets.

PROSPECTing For Antineutrinos

The Precision Reactor Oscillation and Spectrum Experiment (PROSPECT) has completed installation of a novel antineutrino detector that will probe the possible existence of a new form of matter - sterile neutrinos.

How to Cope with Cases of Mistaken Identity: MINERvA's Tale of Pions and Neutrinos

Neutral pion production is a major character in a story of mistaken identity worthy of an Agatha Christie novel.

Perfecting the Noise-Canceling Neutrino Detector

MicroBooNE neutrino experiment cuts through the noise, clearing the way for signals made by the hard-to-detect particle.

Supersonic Waves May Help Electronics Beat the Heat

Researchers at the Department of Energy's Oak Ridge National Laboratory made the first observations of waves of atomic rearrangements, known as phasons, propagating supersonically through a vibrating crystal lattice--a discovery that may dramatically improve heat transport in insulators and enable new strategies for heat management in future electronics devices.

Riding Bacterium to the Bank

Jet fuel, pantyhose and plastic soda bottles are all products currently derived from petroleum. Sandia National Laboratories scientists have demonstrated a new technology based on bioengineered bacteria that makes it feasible to produce all three from renewable plant sources.

Flexible, Highly Efficient Multimodal Energy Harvesting

A piezoelectric ceramic foam supported by a flexible polymer support provides a 10-fold increase in the ability to harvest mechanical and thermal energy over standard piezo composites, according to Penn State researchers.


  • Filters

  • × Clear Filters

Power to the People

The University of Utah College of Engineering has received a $2 million grant to create a laboratory and develop new technology for communities with backup power sources, known as microgrids, so they can quickly and more securely operate in the event of a massive power outage due to a natural disaster or cyberattack.

The U. S. Department of Energy Announces $34 Million for Small Business Research and Development Grants

U.S. Energy Secretary Rick Perry announced that the Department of Energy will award 219 grants totaling $34 million to 183 small businesses in 41 states. Funded through DOE's Small Business Innovation Research (SBIR) and Small Business Technology Transfer (STTR) programs, today's selections are for Phase I research and development.

Raising the Heat to Lower the Cost of Solar Energy

Sandia National Laboratories will receive $10.5 million from the Department of Energy to research and design a cheaper and more efficient solar energy system.The work focuses on refining a specific type of utility-scale solar energy technology that uses mirrors to reflect and concentrate sunlight onto a receiver on a tower.

Solar Turbines, Inc. Selects Penn State to Establish Center of Excellence in Gas Turbines

After completing an extensive evaluation of institutions of higher learning in the United States and Europe, Solar Turbines Incorporated has chosen Penn State as a university partner to establish a center of excellence in gas turbines. The center involves numerous faculty across Penn State's College of Engineering.

ORNL Facility Receives American Nuclear Society's Historic Landmark Designation

The American Nuclear Society has designated the Radiochemical Engineering Development Center at the Department of Energy's Oak Ridge National Laboratory an ANS Nuclear Historic Landmark, recognizing more than 50 years of isotope production and nuclear fuel cycle research.

Steven Cowley named director of DOE's Princeton Plasma Physics Laboratory

Steven Cowley, a theoretical physicist and international authority on fusion energy, has been named director of the U.S. Department of Energy's (DOE) Princeton Plasma Physics Laboratory (PPPL), effective July 1.

Scientists Turn X-ray Laser Into World's Fastest Water Heater

Scientists have used a powerful X-ray laser at the Department of Energy's SLAC National Accelerator Laboratory to heat water from room temperature to 100,000 degrees Celsius in less than a tenth of a picosecond, or millionth of a millionth of a second.

PNNL Part of a New National Center for Near-Atomic Resolution of Biological Molecules

A collaboration between the Pacific Northwest National Laboratory and Oregon Health & Science University has been chosen as a national center for a Nobel Prize-winning method of imaging, cryo-electron microscopy, that is revolutionizing structural biology.

SLAC Will Open One of Three NIH National Service Centers for Cryo-Electron Microscopy

The National Institutes of Health announced today that it will establish a national service and training center for cryogenic electron microscopy research at the Department of Energy's SLAC National Accelerator Laboratory.

Planck Collaboration Wins 2018 Gruber Cosmology Prize

The Planck Team--including researchers in Lawrence Berkeley National Laboratory's (Berkeley Lab's) Computational Research and Physics divisions--have been awarded the 2018 Gruber Cosmology Prize.


  • Filters

  • × Clear Filters

The Secret to Measuring an Antineutrino's Energy

Scientists are developing better models that describe both neutrino and antineutrino data, which can offer insights into the nature of the universe.

How to Cope with Cases of Mistaken Identity: MINERvA's Tale of Pions and Neutrinos

Neutral pion production is a major character in a story of mistaken identity worthy of an Agatha Christie novel.

Perfecting the Noise-Canceling Neutrino Detector

MicroBooNE neutrino experiment cuts through the noise, clearing the way for signals made by the hard-to-detect particle.

Keeping Tabs on Polysulfides in Batteries

Optimizing lithium-sulfur battery electrolytes for long life.

Huge "Thermometer" Takes Temperatures of Tiny Samples

New spectroscopic technique measures heat in itty-bitty volumes that could reveal insights for electronics and energy technology.

Water, Water, Everywhere, but How Does It Flow?

Scientists use new X-ray technique to see how water moves at the molecular level.

Magnetized Plasmas That "Twist Light" Can Produce Powerful Microscopes and More

A non-twisting laser beam moving through magnetized plasma turns into an optical vortex that traps, rotates, and controls microscopic particles, opening new frontiers in imaging.

Whistling While You Work: Fusion Scientists Find Inspiration in Atmospheric Whistles

Just like lightning, fusion plasmas contain odd electromagnetic whistler waves that could control destructive electrons in fusion reactors.

Zero Tolerance in Tokamaks: Eliminating Small Instabilities Before They Become Disruptions

Energetic ions and beam heating cause or calm instabilities, depending on the tokamak's magnetic field.

MURR Becomes First Reactor Facility to Join DOE's Isotope Program

DOE and MURR partner to ensure scientists have access to essential research isotopes.


Spotlight

Monday May 07, 2018, 10:30 AM

Introducing Graduate Students Across the Globe to Photon Science

Brookhaven National Laboratory

Wednesday May 02, 2018, 04:05 PM

Students from Massachusetts and Washington Win DOE's 28th National Science Bowl(r)

Department of Energy, Office of Science

Thursday April 12, 2018, 07:05 PM

The Race for Young Scientific Minds

Argonne National Laboratory

Wednesday March 14, 2018, 02:05 PM

Q&A: Al Ashley Reflects on His Efforts to Diversify SLAC and Beyond

SLAC National Accelerator Laboratory

Thursday February 15, 2018, 12:05 PM

Insights on Innovation in Energy, Humanitarian Aid Highlight UVA Darden's Net Impact Week

University of Virginia Darden School of Business

Friday February 09, 2018, 11:05 AM

Ivy League Graduate, Writer and Activist with Dyslexia Visits CSUCI to Reframe the Concept of Learning Disabilities

California State University, Channel Islands

Wednesday January 17, 2018, 12:05 PM

Photographer Adam Nadel Selected as Fermilab's New Artist-in-Residence for 2018

Fermi National Accelerator Laboratory (Fermilab)

Wednesday January 17, 2018, 12:05 PM

Fermilab Computing Partners with Argonne, Local Schools for Hour of Code

Fermi National Accelerator Laboratory (Fermilab)

Wednesday December 20, 2017, 01:05 PM

Q&A: Sam Webb Teaches X-Ray Science from a Remote Classroom

SLAC National Accelerator Laboratory

Monday December 18, 2017, 01:05 PM

The Future of Today's Electric Power Systems

Rensselaer Polytechnic Institute (RPI)

Monday December 18, 2017, 12:05 PM

Supporting the Development of Offshore Wind Power Plants

Rensselaer Polytechnic Institute (RPI)

Tuesday October 03, 2017, 01:05 PM

Stairway to Science

Argonne National Laboratory

Thursday September 28, 2017, 12:05 PM

After-School Energy Rush

Argonne National Laboratory

Thursday September 28, 2017, 10:05 AM

Bringing Diversity Into Computational Science Through Student Outreach

Brookhaven National Laboratory

Thursday September 21, 2017, 03:05 PM

From Science to Finance: SLAC Summer Interns Forge New Paths in STEM

SLAC National Accelerator Laboratory

Thursday September 07, 2017, 02:05 PM

Students Discuss 'Cosmic Opportunities' at 45th Annual SLAC Summer Institute

SLAC National Accelerator Laboratory

Thursday August 31, 2017, 05:05 PM

Binghamton University Opens $70 Million Smart Energy Building

Binghamton University, State University of New York

Wednesday August 23, 2017, 05:05 PM

Widening Horizons for High Schoolers with Code

Argonne National Laboratory

Saturday May 20, 2017, 12:05 PM

Rensselaer Polytechnic Institute Graduates Urged to Embrace Change at 211th Commencement

Rensselaer Polytechnic Institute (RPI)

Monday May 15, 2017, 01:05 PM

ORNL, University of Tennessee Launch New Doctoral Program in Data Science

Oak Ridge National Laboratory

Friday April 07, 2017, 11:05 AM

Champions in Science: Profile of Jonathan Kirzner

Department of Energy, Office of Science

Wednesday April 05, 2017, 12:05 PM

High-Schooler Solves College-Level Security Puzzle From Argonne, Sparks Interest in Career

Argonne National Laboratory

Tuesday March 28, 2017, 12:05 PM

Champions in Science: Profile of Jenica Jacobi

Department of Energy, Office of Science

Friday March 24, 2017, 10:40 AM

Great Neck South High School Wins Regional Science Bowl at Brookhaven Lab

Brookhaven National Laboratory

Wednesday February 15, 2017, 04:05 PM

Middle Schoolers Test Their Knowledge at Science Bowl Competition

Argonne National Laboratory

Friday January 27, 2017, 04:00 PM

Haslam Visits ORNL to Highlight State's Role in Discovering Tennessine

Oak Ridge National Laboratory

Tuesday November 08, 2016, 12:05 PM

Internship Program Helps Foster Development of Future Nuclear Scientists

Oak Ridge National Laboratory

Friday May 13, 2016, 04:05 PM

More Than 12,000 Explore Jefferson Lab During April 30 Open House

Thomas Jefferson National Accelerator Facility

Monday April 25, 2016, 05:05 PM

Giving Back to National Science Bowl

Ames Laboratory

Friday March 25, 2016, 12:05 PM

NMSU Undergrad Tackles 3D Particle Scattering Animations After Receiving JSA Research Assistantship

Thomas Jefferson National Accelerator Facility

Tuesday February 02, 2016, 10:05 AM

Shannon Greco: A Self-Described "STEM Education Zealot"

Princeton Plasma Physics Laboratory

Monday November 16, 2015, 04:05 PM

Rare Earths for Life: An 85th Birthday Visit with Mr. Rare Earth

Ames Laboratory

Tuesday October 20, 2015, 01:05 PM

Meet Robert Palomino: 'Give Everything a Shot!'

Brookhaven National Laboratory

Tuesday April 22, 2014, 11:30 AM

University of Utah Makes Solar Accessible

University of Utah

Wednesday March 06, 2013, 03:40 PM

Student Innovator at Rensselaer Polytechnic Institute Seeks Brighter, Smarter, and More Efficient LEDs

Rensselaer Polytechnic Institute (RPI)

Friday November 16, 2012, 10:00 AM

Texas Tech Energy Commerce Students, Community Light up Tent City

Texas Tech University

Wednesday November 23, 2011, 10:45 AM

Don't Get 'Frosted' Over Heating Your Home This Winter

Temple University

Wednesday July 06, 2011, 06:00 PM

New Research Center To Tackle Critical Challenges Related to Aircraft Design, Wind Energy, Smart Buildings

Rensselaer Polytechnic Institute (RPI)

Friday April 22, 2011, 09:00 AM

First Polymer Solar-Thermal Device Heats Home, Saves Money

Wake Forest University

Friday April 15, 2011, 12:25 PM

Like Superman, American University Will Get Its Energy from the Sun

American University

Thursday February 10, 2011, 05:00 PM

ARRA Grant to Help Fund Seminary Building Green Roof

University of Chicago

Tuesday December 07, 2010, 05:00 PM

UC San Diego Installing 2.8 Megawatt Fuel Cell to Anchor Energy Innovation Park

University of California San Diego

Monday November 01, 2010, 12:50 PM

Rensselaer Smart Lighting Engineering Research Center Announces First Deployment of New Technology on Campus

Rensselaer Polytechnic Institute (RPI)

Friday September 10, 2010, 12:40 PM

Ithaca College Will Host Regional Clean Energy Summit

Ithaca College

Tuesday July 27, 2010, 10:30 AM

Texas Governor Announces $8.4 Million Award to Create Renewable Energy Institute

Texas Tech University

Friday May 07, 2010, 04:20 PM

Creighton University to Offer New Alternative Energy Program

Creighton University

Wednesday May 05, 2010, 09:30 AM

National Engineering Program Seeks Subject Matter Experts in Energy

JETS Junior Engineering Technical Society

Wednesday April 21, 2010, 12:30 PM

Students Using Solar Power To Create Sustainable Solutions for Haiti, Peru

Rensselaer Polytechnic Institute (RPI)





Showing results

0-4 Of 2215